Open Weekdays 08:30 — 17:30
BMW DPF Cleaning
Restore to As New
Deep Clean Process
We're not talking about an ineffective additive in the fuel tank, we're talking
an off-the-car thorough deep chemical cleaning with a guaranteed result
BMW DPF Diagnosis
Told there's DPF fault?
Horrified by the quote?
Worry not, we are the solution you're looking for.
First we need to confirm the diagnosis (we've seen many wrong guesses!)
and decide on the best solution.
Commonly known as the DPF (short for Diesel Particulate Filter), they are a rather expensive filter designed to collect diesel particulate (carbon and soot) from the exhaust emissions. Essentially a honeycomb design within a metal housing the filter captures the particulate and then treats it at very high temperatures. This is called a regeneration process and results in a short period of smoky emissions. If the regeneration fails or the filter becomes too blocked the system cannot work and warnings will start occurring.
Modern DPF systems include a Diesel Oxidation Catalyst as well as the Diesel Particulate filter encased within the housing.
There are three temperature sensors and two pressure sensors which provide the data to the ECU to determine when regeneration is required.
These sensors must always be operating, even if the filter is bypassed.
EGR, Pressure Sensors, Injectors, Air Leaks, MAF, Turbo and a whole host of other problems can easily cause your DPF to block. We often repair vehicles that have had a DPF filter cleaned or replaced elsewhere only for the filter to block within a matter of days or weeks due to an underlying issue upstream.
The way you drive your car often leads to the DPF blocking. Short journeys, switching the car off whilst its performing a regen (DPF light comes on and people switch the car off despite the handbook advising against). Normally driving style affects the earlier DPF filters more, pre 2010 cars.
Age of Filter
At some point the filter will start to break up, this happens in about 10% of all the DPF filters that we see. Typically with over 150,000 miles on the car or where lots of short journeys with excessive regens. Basically because the filter goes through hot and cold cycles it eventually cracks.
All our work includes a workmanship guarantee & parts warranty.
Our pricing is based on best value for money for a thorough complete job.
We have been doing this for years, you simply cannot beat experience.
We always put you first and our priority is your satisfaction with our services.
Free Courtesy Cars
For your convenience we have a small fleet of courtesy vehicles.
If you're worried about the way the car is driving, we offer recovery too.
We will always try to fit you in for a DPF Initial Assessment same day, just call us, call in or email us to arrange a timeslot.
Most DPF repairs can be completed within one day, so provided we get the car early enough the car will be ready later in the evening. If not, it'll certainly be ready the next day.
BMW Oil Flush & Filter
For best practice we would always recommend having a BMW oil flush and filter renewal with BMW DPF Repairs.
A DPF becoming blocked causes the system to continously attempt regeneration (up until the filter reaches maximum capacity for regen) which involves injecting additional diesel through the system.
This tends to contaminate the oil, hence the recommendation to flush the oil and renew the filter.
From £65 (Avg 4cyl car)
BMW Intake System
An unfortunate side effect of BMW DPF problems tends to be BMW intake system carbon buildup.
Basically the soot and carbon deposits from the diesel system coke up the intake pipes, manifolds, egr valves etc. The volume of soot and carbon is much increased once the DPF becomes blocked and inefficient.
We offer multiple BMW intake system decarb options, you'll receive more information from your customer service advisor.
From £95 (Most Cars)
BMW Intake System
One of the main causes we find for BMW DPF and BMW carbon problems is an undetected BMW intake system leak.
A small split in a pipe may not cause sufficient deviation from expected values for a BMW MAF fault code to trigger, however it will be having an effect on the carbon build up and subsequent DPF status.
We offer an BMW Smoke Pro Plus leak detector test which will highlight any intake system leaks.
From £25 (Basic Check)
BMW EGR Valve
BMW Exhaust Gas Recirculation basically recirculates a portion of exhaust gases back into the engine cylinders.
The valve is controlled by either a vacuum based or an electronic actuator valve which opens or closes to admit the exhaust under certain conditions. EGR Valve actuators stuck open or closed cause DPF issues.
BMW EGR Valve cleaning can help, alternatively a new part may be required.
From £125 (Ultrasonic Cleaning)
BMW EGR Valve
BMW EGR Valves can be unreliable and cause problems and as they are a quite expensive part it has become popular under certain circumstances to blank the valve and bypass it from the system.
Mechanical blanking off is required and an engine ECU map adjustment to maintain emission standards.
There are pros & cons to all modifications, request an info pack or ask about this.
From £295 (Full Process)
BMW Swirl Flap
BMW Swirl Flaps are small butterly valves fitted to the intake manifold just before the cylinder head intake ports and operated with either a vacuum based or electronic servo mechanism.
BMW Carbon build up on the flaps cause them to stick in one position and strain the system. Flaps can break & get sucked though the engine causing catastrophic failure.
BMW Swirl Flap Bypass is therefore very popular as a precaution.
From £165 (Full Process)
BMW Mass Air Flow
The BMW MAF sensor is used to measure the mass flow rate of air entering the engine.
The purpose of this is for the engine control unit to calculate the correct fuel mass. This means that if the mass air flow sensor or associated pipes have a fault, the engine will over or under fuel. This tends to increase carbon build up.
BMW MAF faults need resolving.
From £55 (Diagnosis)
BMW Sensor Faults
The multitude of BMW sensors on the intake and exhaust system are all linked to the whole system running correctly.
Any BMW sensor faults can trigger error codes & poor running. Even minor inefficiencies or variations can cause carbon build up or inoperation of the BMW DPF regeneration process. A sure way to get a blocked DPF.
BMW Sensor faults need identifying.
From £55 (Diagnosis)
BMW Injector Problems
The injectors obviously inject the fuel entering the engine.
If an injector develops a fault the engine will be over or under fuelling. Not only is this bad for the cylinders but it will also lead to increased carbonisation and soot build up. BMW injector bench testing tends to be the best way of confirming injector status.
BMW Injector cleaning is popular.
From £15 (Per Injecter Test)
BMW Turbo Actuator
The BMW turbo actuator (also known as BMW wastegate actuator) is responsible for controlling the boost output from the turbo by providing a pressure release valve diverting the gases away from the turbine wheel.
Pressure & heat are a recipe for wear & tear. The actuator spring will weaken & allow premature opening or the diagphram could fail.
An EML will likely illuminate, always get this checked!
From £55 (Diagnosis)
BMW Turbo Problems
The BMW turbocharger works hard and if a problem does develop it would be wise not to ignore it!
Turbochargers get carbonised just like the rest of the system and an BMW Turbo ChemClean will do wonders as a preventative maintenance routine. Keeping the turbine clean definitely increases longevity.
We offer Turbo ChemCleaning or in worse case scenarios replacement of the turbocharger.
From £65 (Turbo ChemClean)
All engines produce carbon as a side effect of the engine combustion process. BMW Carbon Buildup Causes All Sorts of Problems!
Unfortunately not all of the carbon gets emitted via the exhaust system (to be filtered by the DPF), with modern recircularisation systems carbon deposits build up in the intake system. BMW Decarbonisation prevents bigger issues.
We offer BMW Additive Treatments, BMW Chemical Cleaning & BMW Walnut Blasting.
From £95 (ChemCleaning)
- BMW DPF Services South Wales
- BMW DPF Services Bridgend
- BMW DPF Services Cardiff
- BMW DPF Services Swansea
- BMW DPF Services Newport
- BMW DPF Services Chepstow
- BMW DPF Cleaning South Wales
- BMW DPF Cleaning Bridgend
- BMW DPF Cleaning Cardiff
- BMW DPF Cleaning Swansea
- BMW DPF Cleaning Newport
- BMW DPF Cleaning Chepstow
- BMW DPF Delete South Wales
- BMW DPF Delete Bridgend
- BMW DPF Delete Cardiff
- BMW DPF Delete Swansea
- BMW DPF Delete Newport
- BMW DPF Delete Chepstow