Open Weekdays 08:30 — 17:30
Audi DPF Cleaning
Restore to As New
Deep Clean Process
We're not talking about an ineffective additive in the fuel tank, we're talking
an off-the-car thorough deep chemical cleaning with a guaranteed result
Audi DPF Diagnosis
Told there's DPF fault?
Horrified by the quote?
Worry not, we are the solution you're looking for.
First we need to confirm the diagnosis (we've seen many wrong guesses!)
and decide on the best solution.
Commonly known as the DPF (short for Diesel Particulate Filter), they are a rather expensive filter designed to collect diesel particulate (carbon and soot) from the exhaust emissions. Essentially a honeycomb design within a metal housing the filter captures the particulate and then treats it at very high temperatures. This is called a regeneration process and results in a short period of smoky emissions. If the regeneration fails or the filter becomes too blocked the system cannot work and warnings will start occurring.
Modern DPF systems include a Diesel Oxidation Catalyst as well as the Diesel Particulate filter encased within the housing.
There are three temperature sensors and two pressure sensors which provide the data to the ECU to determine when regeneration is required.
These sensors must always be operating, even if the filter is bypassed.
EGR, Pressure Sensors, Injectors, Air Leaks, MAF, Turbo and a whole host of other problems can easily cause your DPF to block. We often repair vehicles that have had a DPF filter cleaned or replaced elsewhere only for the filter to block within a matter of days or weeks due to an underlying issue upstream.
The way you drive your car often leads to the DPF blocking. Short journeys, switching the car off whilst its performing a regen (DPF light comes on and people switch the car off despite the handbook advising against). Normally driving style affects the earlier DPF filters more, pre 2010 cars.
Age of Filter
At some point the filter will start to break up, this happens in about 10% of all the DPF filters that we see. Typically with over 150,000 miles on the car or where lots of short journeys with excessive regens. Basically because the filter goes through hot and cold cycles it eventually cracks.
All our work includes a workmanship guarantee & parts warranty.
Our pricing is based on best value for money for a thorough complete job.
We have been doing this for years, you simply cannot beat experience.
We always put you first and our priority is your satisfaction with our services.
Free Courtesy Cars
For your convenience we have a small fleet of courtesy vehicles.
If you're worried about the way the car is driving, we offer recovery too.
We will always try to fit you in for a DPF Initial Assessment same day, just call us, call in or email us to arrange a timeslot.
Most DPF repairs can be completed within one day, so provided we get the car early enough the car will be ready later in the evening. If not, it'll certainly be ready the next day.
Audi Oil Flush & Filter
For best practice we would always recommend having an Audi oil flush and filter renewal with Audi DPF Repairs.
A DPF becoming blocked causes the system to continously attempt regeneration (up until the filter reaches maximum capacity for regen) which involves injecting additional diesel through the system.
This tends to contaminate the oil, hence the recommendation to flush the oil and renew the filter.
From £65 (Avg 4cyl car)
Audi Intake System
An unfortunate side effect of Audi DPF problems tends to be Audi intake system carbon buildup.
Basically the soot and carbon deposits from the diesel system coke up the intake pipes, manifolds, egr valves etc. The volume of soot and carbon is much increased once the DPF becomes blocked and inefficient.
We offer multiple Audi intake system decarb options, you'll receive more information from your customer service advisor.
From £95 (Most Cars)
Audi Intake System
One of the main causes we find for Audi DPF and Audi carbon problems is an undetected Audi intake system leak.
A small split in a pipe may not cause sufficient deviation from expected values for an Audi MAF fault code to trigger, however it will be having an effect on the carbon build up and subsequent DPF status.
We offer an Audi Smoke Pro Plus leak detector test which will highlight any intake system leaks.
From £25 (Basic Check)
Audi EGR Valve
Audi Exhaust Gas Recirculation basically recirculates a portion of exhaust gases back into the engine cylinders.
The valve is controlled by either a vacuum based or an electronic actuator valve which opens or closes to admit the exhaust under certain conditions. EGR Valve actuators stuck open or closed cause DPF issues.
Audi EGR Valve cleaning can help, alternatively a new part may be required.
From £125 (Ultrasonic Cleaning)
Audi EGR Valve
Audi EGR Valves can be unreliable and cause problems and as they are a quite expensive part it has become popular under certain circumstances to blank the valve and bypass it from the system.
Mechanical blanking off is required and an engine ECU map adjustment to maintain emission standards.
There are pros & cons to all modifications, request an info pack or ask about this.
From £295 (Full Process)
Audi Swirl Flap
Audi Swirl Flaps are small butterly valves fitted to the intake manifold just before the cylinder head intake ports and operated with either a vacuum based or electronic servo mechanism.
Audi Carbon build up on the flaps cause them to stick in one position and strain the system. Flaps can break & get sucked though the engine causing catastrophic failure.
Audi Swirl Flap Bypass is therefore very popular as a precaution.
From £165 (Full Process)
Audi Mass Air Flow
The Audi MAF sensor is used to measure the mass flow rate of air entering the engine.
The purpose of this is for the engine control unit to calculate the correct fuel mass. This means that if the mass air flow sensor or associated pipes have a fault, the engine will over or under fuel. This tends to increase carbon build up.
Audi MAF faults need resolving.
From £55 (Diagnosis)
Audi Sensor Faults
The multitude of Audi sensors on the intake and exhaust system are all linked to the whole system running correctly.
Any Audi sensor faults can trigger error codes & poor running. Even minor inefficiencies or variations can cause carbon build up or inoperation of the Audi DPF regeneration process. A sure way to get a blocked DPF.
Audi Sensor faults need identifying.
From £55 (Diagnosis)
Audi Injector Problems
The injectors obviously inject the fuel entering the engine.
If an injector develops a fault the engine will be over or under fuelling. Not only is this bad for the cylinders but it will also lead to increased carbonisation and soot build up. Audi injector bench testing tends to be the best way of confirming injector status.
Audi Injector cleaning is popular.
From £15 (Per Injecter Test)
Audi Turbo Actuator
The Audi turbo actuator (also known as Audi wastegate actuator) is responsible for controlling the boost output from the turbo by providing a pressure release valve diverting the gases away from the turbine wheel.
Pressure & heat are a recipe for wear & tear. The actuator spring will weaken & allow premature opening or the diagphram could fail.
An EML will likely illuminate, always get this checked!
From £55 (Diagnosis)
Audi Turbo Problems
The Audi turbocharger works hard and if a problem does develop it would be wise not to ignore it!
Turbochargers get carbonised just like the rest of the system and an Audi Turbo ChemClean will do wonders as a preventative maintenance routine. Keeping the turbine clean definitely increases longevity.
We offer Turbo ChemCleaning or in worse case scenarios replacement of the turbocharger.
From £65 (Turbo ChemClean)
All engines produce carbon as a side effect of the engine combustion process. Audi Carbon Buildup Causes All Sorts of Problems!
Unfortunately not all of the carbon gets emitted via the exhaust system (to be filtered by the DPF), with modern recircularisation systems carbon deposits build up in the intake system. Audi Decarbonisation prevents bigger issues.
We offer Audi Additive Treatments, Audi Chemical Cleaning & Audi Walnut Blasting.
From £95 (ChemCleaning)
- Audi DPF Services South Wales
- Audi DPF Services Bridgend
- Audi DPF Services Cardiff
- Audi DPF Services Swansea
- Audi DPF Services Newport
- Audi DPF Services Chepstow
- Audi DPF Cleaning South Wales
- Audi DPF Cleaning Bridgend
- Audi DPF Cleaning Cardiff
- Audi DPF Cleaning Swansea
- Audi DPF Cleaning Newport
- Audi DPF Cleaning Chepstow
- Audi DPF Delete South Wales
- Audi DPF Delete Bridgend
- Audi DPF Delete Cardiff
- Audi DPF Delete Swansea
- Audi DPF Delete Newport
- Audi DPF Delete Chepstow